Hyundai i20 Quiz
Body Work (Interior and Exterior)

Headliner Repair Procedures

In this manual: Body Work (Interior and Exterior)
General Information — 17Engine Mechanical System — 79Engine Electrical System — 50Emission Control System — 22Engine/Fuel Control System — 107Clutch System — 27MANUAL TRANSMISSION SYSTEM — 21Drive Shaft and Axle — 18Suspension System — 29Steering System — 21Restraint — 41Braking System — 53Body Work (Interior and Exterior) — 190Body Electrical System — 181Heating, Ventilation and Air Conditioning — 58
17steps
~102min
4/5difficulty
Done 0 of 17

REPLACEMENT

  1. Remove the front seat. (Refer to Front Seat - "Front Seat")
  2. Remove the rear seat. (Refer to Rear Seat - "Rear Seat")
  3. Remove the front pillar garnish. (Refer to Interior Trim - "Front Pillar Trim")
  4. Remove the upper center pillar trim. (Refer to Body Trim - "Center Pillar Trim")
  5. Remove the rear pillar garnish. (Refer to Interior Trim - "Rear Pillar Trim")
  6. Remove the auxiliary sun visor. (Refer to Headliner - "Sun Visors")
  7. Remove the sun visor and holder. (Refer to Headliner - "Sun Visors")
  8. Remove the grab handle. (Refer to Headliner - "Passenger Grab Handle")
  9. Remove the lamp from the overhead console. (Refer to Body Electrical System - "Overhead Console Lamp")
  10. Remove the room lamp. (Refer to Body Electrical System - "Cabinet Lamp")
  11. Disconnect the ECM mirror connector. (Refer to Body Electrical System - "Inside Rear View Mirror (Electrochromic)")
  12. Disconnect the main headliner connectors (A) and the clips on the front pillar. [Driver]
    [Passenger]
  13. Remove the headliner clip, then remove the headliner (A).
  14. Disconnect the main roof connector (A).
  15. Remove the dome light.
  16. Remove the headliner wiring harness (A) from the headliner (B).
  17. To install, perform the removal procedure in reverse order.

Test yourself

A quick Hyundai i20 quiz: every answer comes with an explanation and a link to the manual page.