Hyundai Tucson Quiz
Body Work (Interior and Exterior)

Troubleshooting

In this manual: Body Work (Interior and Exterior)
General Information — 17Engine Mechanical System — 51Engine Electrical System — 26Emission Control System — 23Engine/Fuel Control System — 44Clutch System — 12MANUAL TRANSMISSION SYSTEM — 12AUTOMATIC TRANSMISSION SYSTEM — 42Four-Wheel Drive (4WD) System — 14Drive Shaft and Axle — 22Suspension System — 30Steering System — 16Restraint — 21Braking System — 47Body Work (Interior and Exterior) — 145Body Electrical System — 162Heating, Ventilation and Air Conditioning — 39
~1min read

TROUBLESHOOTING

Symptom Possible Cause Remedy (Refer to page)
Water Leakage through Panoramic Sunroof Damaged Roof Seal Replace
Excessive Gap between Roof and Body and Improper Seal Installation adjust
Wind Noise Around Sunroof Loose or Deformed Deflector, Gaps in Body Tighten, adjust, or replace
Noise Caused by Panoramic Sunroof Glass Movement Foreign Material Stuck in Sliding Rail Guide Check the guide cable and guides to make sure there is no foreign material
Free the guides and glass Tighten
Motor Runs but Sunroof Does Not Move or Moves Only Partially Foreign Material Stuck in Sliding Rail Guide Adjust or replace.
Improper Engagement of Motor Gear with Guide Cable
Reduce engine clutch slippage
Increased resistance of the sliding roof or interference of the roof with the drive cables, weatherstrip, etc. due to improper roof adjustment
Engine noise (engine clutch slipping noise when the sunroof is fully open or closed) is still considered Improper Engagement of Motor Gear with Guide Cable Check the installation of the sprocket and
Tighten the motor
Damaged or worn engine sprocket holder Replace the engine assembly
Deformed or worn control cable Replace
Door window cannot be lowered or raised Glass is installed incorrectly Adjust its position
Window regulator or window regulator lever is damaged or faulty Repair or replace
Door cannot be closed or fully opened Door is installed incorrectly Adjust its position
Door assembly is faulty Repair or replace
Door hinge is insufficiently lubricated Lubricants
Hood cannot be fully opened or closed Hinge pin and latch are not properly aligned adjust
Hood is installed incorrectly adjust
Incorrect gap between bumper and hood adjust
Water leakage through the windshield and rear window Seal is faulty Seal with weatherstrip
Edge of windshield or rear window glass is defective Correct

Test yourself

A quick Hyundai Tucson quiz: every answer comes with an explanation and a link to the manual page.