Toyota Sienna Quiz
Seat

Disassembly

In this manual: Seat
Introduction — 55Service specifications — 7Maintenance — 7Engine — 264U151e automatic transaxle — 108Transfer — 19Propeller shaft — 8Drive shaft — 14Differential — 16Axle — 18Suspension — 37Tire and wheel — 54Brake control — 141Parking brake — 16Steering Column — 11Power steering — 18Air conditioning — 106Supplemental restraint system — 146Seat belt — 22Theft deterrent — 14Engine immobiliser — 17Cruise control — 65Lighting — 61Wiper and washer — 13Door lock — 42Meter — 28Audio / visual — 94Navigation — 108Park assist / monitoring — 33Horn — 5Garage door opener — 42GR-FE Engine control system — 126Supplemental restraint system — 147Other system — 14Windshield / windowglass — 43Mirror — 23Instrument panel — 6Seat belt — 22Seat — 92Engine hood / door — 104Exterior — 39Interior — 5Sliding roof — 9Multiplex communication — 18Can communication — 23
20steps
~120min
4/5difficulty
Done 0 of 20

1. REMOVE FRONT SEAT SIDE TABLE LEG COVER (w/ Table)

  1. Using a screwdriver, disengage the claws and remove the seat side table leg cover.

HINT: Tape the screwdriver tip before use.

2. REMOVE FRONT SEAT SIDE TABLE (w/ Table)

  1. Remove the 4 nuts and seat side table.
  2. Remove the 2 clips and seat side table cover.

3. REMOVE OCCUPANT CLASSIFICATION ECU (for Front Passenger Seat)

4. REMOVE RECLINING POWER SEAT SWITCH KNOB

REMOVE RECLINING POWER SEAT SWITCH KNOB
  1. Using a screwdriver, remove the reclining power seat switch knob.

HINT: Tape up the screwdriver tip before.

5. REMOVE SLIDE & VERTICAL POWER SEAT SWITCH KNOB

  1. Using a screwdriver, remove the slide & vertical power seat switch knob.

HINT: Tape up the screwdriver tip before.

6. REMOVE FRONT SEAT CUSHION SHIELD INNER LH

  1. Remove the 7 screws.
  2. Using a screwdriver, disengage the 4 claws and clip, and remove the front seat cushion shield LH together with the front seat cushion shield inner LH and front seat cushion shield inner No. 1 LH.

HINT: Tape the screwdriver tip before use.

REMOVE FRONT SEAT CUSHION SHIELD INNER LH
  1. Remove the screw and front seat cushion shield inner LH from the front seat cushion shield inner No.
1 LH.

7. REMOVE NO. 1 FRONT SEAT CUSHION SHIELD INNER LH

  1. Remove the screw and front seat cushion shield inner No. 1 LH from the front seat cushion shield LH.

8. REMOVE POWER SEAT SWITCH (for Driver Seat)

REMOVE POWER SEAT SWITCH
  1. Remove the 2 screws and the power seat switch.

9. REMOVE FRONT POWER SEAT SWITCH LH

  1. Disconnect the connector.
  2. Remove the 3 screws and power seat switch LH.

10. REMOVE FRONT SEAT INNER BELT ASSEMBLY LH

  1. Disconnect the connectors.
  2. Remove the nut and inner belt assembly.

11. REMOVE FRONT SEAT TRACK COVER LH FRONT OUTER

  1. Remove the clip, 2 screws and seat track cover front outer.

12. REMOVE FRONT SEAT TRACK COVER LH FRONT INNER

  1. Remove the clip, 2 screws and seat track cover front inner.

13. REMOVE FRONT SEAT INNER LH ARMREST ASSEMBLY

REMOVE FRONT SEAT INNER LH ARMREST ASSEMBLY
  1. Using a screwdriver, pry out the armrest cap.
HINT: Tape the screwdriver tip before use.
  • Remove the bolt and armrest assembly.
  • Remove the 2 washers and 2 spacers.

    • 14. REMOVE SEAT CUSHION COVER WITH PAD

    REMOVE SEAT CUSHION COVER WITH PAD
    1. with Seat heater: Disconnect the connector.
    2. Disengage the clamps and hooks.
    3. Disengage the hooks and remove the seat cushion cover with pad.

    15. REMOVE SEPARATE TYPE FRONT SEAT CUSHION COVER

    1. Remove the hog rings and the separate type front seat cushion cover.

    16. REMOVE FRONT SEAT CUSHION HEATER ASSEMBLY LH (w/ Seat Heater System)

    1. Cut off the tack pins which fasten the seat heater and then remove the front seat heater from the cushion cover.

    NOTICE: Be careful not to damage the seat cushion cover.

    17. REMOVE FRONT SEATBACK BOARD LH

    REMOVE FRONT SEATBACK BOARD LH
    1. Disengage the clips.
    2. Remove the seatback board by pulling it out in the arrow mark direction shown in the illustration.

    18. REMOVE FRONT SEAT HEADREST SUPPORT

    REMOVE FRONT SEAT HEADREST SUPPORT
    1. Disengage the claw and remove the 2 headrest supports.

    19. REMOVE SEATBACK COVER WITH PAD

    REMOVE SEATBACK COVER WITH PAD
    1. with Side airbag: Remove the nut and disengage the separate type front seatback cover bracket.
    2. Remove the hog rings and disengage the hooks.
    3. Remove the seatback cover with pad.

    20. REMOVE FRONT SEATBACK COVER LH

    REMOVE FRONT SEATBACK COVER LH
    1. Remove the hog rings and the front seatback cover.

    21. REMOVE FRONT SEATBACK HEATER ASSEMBLY LH (w/ Seat Heater System)

    1. Cut off the tack pins which fasten the seat heater and then remove the front seat heater from the front seatback cover.

    NOTICE: Be careful not to damage the seatback cover.

    22. REMOVE RECLINING ADJUSTER INSIDE COVER LH

    REMOVE RECLINING ADJUSTER INSIDE COVER LH
    1. Remove the 2 screws and the reclining adjuster inside cover LH (lower).

    23. REMOVE RECLINING ADJUSTER INSIDE COVER RH

    REMOVE RECLINING ADJUSTER INSIDE COVER RH
    1. Disengage the clamp.
    2. Remove the 2 screws and the reclining adjuster inside cover RH (lower).

    24. REMOVE RECLINING ADJUSTER INSIDE COVER LH

    REMOVE RECLINING ADJUSTER INSIDE COVER LH
    1. Remove the screw and the reclining adjuster inside cover LH (upper).

    25. REMOVE RECLINING ADJUSTER INSIDE COVER RH

    HINT: Use the same procedures for the RH side and LH side.

    26. REMOVE FRONT SEAT CUSHION SHIELD LOWER LH

    REMOVE FRONT SEAT CUSHION SHIELD LOWER LH
    1. Remove the screw and the front seat cushion shield lower LH.

    27. REMOVE FRONT SEAT CUSHION SHIELD LOWER RH

    HINT: Use the same procedures for the RH side and LH side.

    28. REMOVE LUMBAR SUPPORT ADJUSTER ASSEMBLY LH (for Driver Seat)

    REMOVE LUMBAR SUPPORT ADJUSTER ASSEMBLY LH
    1. Disconnect the connector.
    2. Remove the 2 screws and the lumbar support adjuster assembly LH.

    29. REMOVE SEAT POSITION AIRBAG SENSOR (for Driver Seat)

    Test yourself

    A quick Toyota Sienna quiz: every answer comes with an explanation and a link to the manual page.