Volkswagen Golf Quiz
General body repairs, interior

Removing and installing trim panel

In this manual: General body repairs, interior
General body repairs, exterior — 230General body repairs, interior — 279General information, paint — 133Vechile- specific paint information — 27Heating, air conditioning — 156Auxiliary heater — 58Air conditioning system with refrigerant R134a — 1297- speed dual clutch gearbox 0CW — 544- cylinder injection engine(1.4 1 direct inction. turbocharger) — 182Fuel supply system - Petrol engines — 59Running gear, axles, steering — 221Brake system — 92Wheels and Tyres guide — 12Guide for using trailers — 11Wheels and Tyres Guide - General Information — 121Brake system (hybrid) — 73Electrical system — 326Communication — 65Electrical system, general information — 111
~1min read
Note Removal and installation are described for the trim panel on driver side. Follow same instructions for the front passenger side as appropriate.

Removing

  • Remove rear door trim → Chapter.
  • Using an appropriate drill bit, drill mounting points -2- of trim panel -1- off door trim, but just until trim panel starts to detach from door trim.
Caution

The door trim must not be damaged when drilling.
  • Carefully release mounting points -2- one after the other and remove trim panel -1- from door trim.
Removing and installing trim panel

Installing

Clamping washers near trim panel: qty. 7, 17 mm Ч 7.5 mm. Allocation → Electronic Parts Catalogue Clamping washers near inner door handle: qty. 6, 13.4 mm Ч 6 mm. Allocation → Electronic Parts Catalogue
  • Insert new trim panel -1- into door trim.
  • Press clamping washers -2- as far as stop onto pins -3- of trim panel.
  • Press remaining clamping washers onto pins of trim panel near inner door handle as described.
  • Cut back pins -3- of trim panel above clamping washers -2- to max. 2 mm beyond washers.
  • Install rear door trim → Chapter.
Removing and installing trim panel

Test yourself

A quick Volkswagen Golf quiz: every answer comes with an explanation and a link to the manual page.