Toyota Corolla Quiz
Heater & air conditioner

Replacement

In this manual: Heater & air conditioner
Introduction — 31Preparation — 32Service specifications — 19Diagnostics — 497Engine control system — 6Fuel — 13Emission control — 28Exhaust — 3Cooling — 13Lubrication — 7Ignition — 3Starting & charging — 13Front suspension — 12Rear suspension — 9Tire & wheel — 1Drive shaft / propeller shaft — 15Brake — 42Automatic transmission / trans — 47Clutch — 19Steering column — 9Power steering — 11Heater & air conditioner — 20Supplemental restraint system — 27Seat belt — 12Lighting — 18Wiper & washer — 9Audio & visual — 12Wiring — 1Communication system — 1Windshield/windowglass/mirror — 31Seat — 10Theft deterrent & door lock — 10Sliding roof/convertible — 8Engine hood/door — 12Exterior/interior trim — 20Vehicle control system — 1Cruise control — 5Maintenance — 8
6steps
~36min
2/5difficulty
Done 0 of 6
1. Discharge refrigerant from refrigeration system
  1. turn the a/c switch on.
  2. operating the cooler compressor at the engine rpm of approx. 1000 For 5 to 6 min., Circulate the refrigerant and collect compressor oil remaining in each component into the cooler compressor as much as possible.
  3. stop the engine.
  4. let the refrigerant gas out.

    Sst 07110–58060 (07117–58080, 07117–58090, 07117–78050, 07117–88060, 07117–88070, 07117–88080)

2. Charge refrigerant
  1. using a vacuum pump, perform a vacuum pumping.
  2. supply refrigerant, hfc–134a (r134a).

    Standard: 490 30 g (17.28 1.06 Oz.) Sst 07110–58060 (07117–58060, 07117–58070, 07117–58080, 07117–58090, 07117–78050, 07117–88060, 07117–88070, 07117–88080), 07117–48130, 07117–48140

3. Warm up engine 4. Inspect leakage of refrigerant
  1. using a gas leak detector, check for leakage of refrigerant.

Test yourself

A quick Toyota Corolla quiz: every answer comes with an explanation and a link to the manual page.