Hyundai Tucson Quiz
Body Work (Interior and Exterior)

Headliner

In this manual: Body Work (Interior and Exterior)
General Information — 17Engine Mechanical System — 51Engine Electrical System — 26Emission Control System — 23Engine/Fuel Control System — 44Clutch System — 12MANUAL TRANSMISSION SYSTEM — 12AUTOMATIC TRANSMISSION SYSTEM — 42Four-Wheel Drive (4WD) System — 14Drive Shaft and Axle — 22Suspension System — 30Steering System — 16Restraint — 21Braking System — 47Body Work (Interior and Exterior) — 145Body Electrical System — 162Heating, Ventilation and Air Conditioning — 39
25steps
~150min
5/5difficulty
Done 0 of 25

Components and Component Location

COMPONENT LOCATION

1. Headliner

Repair Procedures

REPLACEMENT

  1. Remove the door weatherstrip.
  2. Remove the front pillar garnish. (Refer to Interior Trim - "Front Pillar Garnish")
  3. Remove the center pillar lower garnish. (Refer to Interior Trim - "Center Pillar Garnish")
  4. Remove the center pillar upper garnish. (Refer to Interior Trim - "Center Pillar Garnish")
  5. Remove the luggage compartment side trim. (Refer to Interior Trim - "Luggage Compartment Side Trim")
  6. Remove the rear pillar garnish. (Refer to Interior Trim - "Rear Pillar Trim")
  7. Remove the sun visor and clip. (Refer to Roof Trim - "Sun Visor")
  8. Remove the assist grip. (Refer to Roof Trim - "Assist Grip")
  9. Remove the lamp from the overhead console. (Refer to Body Electrical System - "Overhead Console Lamp")
  10. Remove the room lamp. (Refer to Body Electrical System - "Room Lamp")
  11. Remove the trunk lamp. (Refer to Body Electrical System - "Trunk Lamp")
  12. Fully recline the front seatback.
  13. Fold the rear seat by sliding it fully forward as far as possible.
  14. Remove the ECM mirror cover (A).
  15. Remove the rain sensor cover (A).
  16. Disconnect the LDWS connector (A) and the rain sensor connector (B).
  17. Disconnect the mirror ECM connector (C) and the auto anti-fog connector (D).
  18. Disconnect the headliner main connector (A) and the clips in the front pillar. [Driver]
    [Passenger]
  19. Disconnect the roof wiring connector (A).
  20. Carefully remove the tailgate weatherstrip.
  21. Disconnect the roof antenna connector (A).
  22. Remove the headliner (A) from the vehicle through the rear door.
  23. Remove the dome light. (Refer to Body Electrical System - "Lighting")
  24. Remove the headliner wiring harness (A) from the headliner (B).
  25. To install, perform the removal procedure in reverse order.

Test yourself

A quick Hyundai Tucson quiz: every answer comes with an explanation and a link to the manual page.