Kia Stinger CK Quiz

Body (Interior and Exterior)

In this manual: Body (Interior and Exterior)
General Information — 8Maintenance — 27Engine Mechanical System — 47Engine Electrical System — 19Emission Control System — 12Engine Control System/Fuel System — 51Automatic Transmission System — 34All-Wheel Drive (AWD) System — 7Drive Shaft and Axle — 15Suspension System — 25Steering — 8Restraints — 19Brake System — 22Body (Interior and Exterior) — 47Front Seat Belt — 63Body Electrical System — 99Windshield Wiper/Washer — 11Heating, Ventilation, and Air Conditioning — 32
~2min read
1special tools

Special Service Tools

Special Service Tools

Tool (Number and Name) Illustration Use
09880-4F000
Weld Nut Clip Installer
Weld Nut Clip Installation
0K888-D42000
Quick Release Connector EFD
Used to remove the EFD quick connector.

Troubleshooting

Troubleshooting

Symptom Suspected Area Remedy (Refer to page)
Water Leaks from Sunroof Dirt Accumulated in Drain Tube Clean dirt from the drain.
Clogged Drain Tube Blow air into the drain to remove dirt
Broken or displaced drain tube, defective or cracked clamp Check the tube installation and flange contact
Worn Roof Cover Seal Replace
Excessive gap between the roof panel and the body, and incorrectly installed weatherstrip Adjust
Wind Noise Around Sunroof Loose or deformed deflector, body gaps Tighten, adjust, or replace
Displaced seal Adjust or replace the seal.
Sunroof noise while driving Foreign material caught in the guide rail Check the drive cable and guide rails for foreign material.
Loose guide rails and sunroof panel Tighten
Motor operates but sunroof does not move or moves partially Foreign material caught in the guide rail Adjust or replace
Motor pinion gear incorrectly engaged with drive cable
Reduced Sunroof Slip Force
Increased sliding resistance of the sunroof or interference with the drive cable, seal, etc. due to improper sunroof adjustment
Motor noise (sunroof motor clutch slip noise when the sunroof is fully open or closed) is considered normal Motor pinion gear incorrectly engaged with drive cable Check the gear installation and tighten the motor.
Worn or damaged motor pinion gear bearing Replace the motor assembly
Worn or deformed drive cable Replace
Door glass does not move up or down Incorrectly installed window glass Adjust the position
Damaged or faulty regulator arm or regulator Repair or replace
Door does not open or close fully Incorrectly installed door Adjust the position
Faulty door lock assembly Repair or replace
Striker and latch are not properly aligned Readjust
Door hinge requires lubrication Apply grease
Hood does not open or close fully Striker and latch are not properly aligned Adjust
Incorrectly installed hood seal Adjust
Incorrect hood bumper height Adjust
Water leaks through the rear window from the windshield side Defective seal Apply sealant
Defective flange Correct

Test yourself

A quick Kia Stinger CK quiz: every answer comes with an explanation and a link to the manual page.