Hyundai Kona Quiz
Engine Control System/Fuel System

DC/DC Converter Repair Procedures

In this manual: Engine Control System/Fuel System
General Information — 17Engine Mechanical System — 85Engine Electrical System — 50Emission Control System — 26Engine Control System/Fuel System — 152DCT (Dual Clutch Transmission) System — 50Four-Wheel Drive (4WD) System — 21Propeller Shaft and Axle (2WD-FF) — 28Suspension System (without ECS) — 32Steering — 21Restraints — 38Brake System — 64Body (Interior and Exterior) — 205Body Electrical System — 1Heating, Ventilation, and Air Conditioning — 66
8steps
~48min
2/5difficulty
Done 0 of 8

Removal

[200 W]
  1. Turn the ignition switch OFF and disconnect the negative (-) battery terminal.
  2. Remove the emergency pad lower panel. (Refer to Body - "Emergency Pad Lower Panel")
  3. Disconnect the DC/DC converter connector.
  4. Remove the DC/DC converter (B) after removing the nuts (A).
  5. Turn the ignition switch OFF and disconnect the negative (-) battery terminal.
  6. Remove the heater and A/C control unit. (Refer to Heating, Ventilation and Air Conditioning - Heater and A/C Control Unit.)
  7. Disconnect the DC/DC converter connector (A).
  8. Remove the DC/DC converter (B) after removing the screws and nuts.
[450 W]

Installation

  1. Install in the reverse order of removal.

Test yourself

A quick Hyundai Kona quiz: every answer comes with an explanation and a link to the manual page.