Volvo S80 Quiz
Starting and driving

Fuel filler flap - opening/closing. Fuel filler flap - manual opening. Refueling. Fuel - handling

In this manual: Starting and driving
Introduction — 9Safety — 9Instruments and controls — 29Climate control — 12Loading and storage. Storage compartments. Center console. Glove compartment. Center console 12 V socket — 1Loading and storage. Loading. Loading - ski hatch. Roof load. Cargo tie-down eyes — 1Loading and storage. Loading - shopping bag holder*. 12 V socket in luggage compartment* — 1Locks and Alarm System — 14Driver assistance — 33Starting and driving — 29Wheels and tires — 15Care and Service — 24Technical data. Type designations. Weights. Towing weight and nose weight. Engine technical data — 1Technical data. Engine oil - severe operating conditions. Engine oil - quality and capacity. Coolant - quality and capacity. Transmission fluid - quality and capacity — 1Technical Data. Technical data for the air conditioning system. Fuel consumption and CO2 emissions. Tires - approved tire pressure — 1
2steps
~12min
1/5difficulty
Done 0 of 2

The fuel filler flap operation on the Volvo S80 (2nd generation, 2013–2016) is designed for convenience and safety. This section explains electrical and manual opening, the refueling process, and how to handle the fuel cap. Safety information on fuel handling is also provided. Tips on selecting the correct fuel and avoiding overfilling support responsible use.

Fuel filler flap - opening/closing

The fuel filler flap can be opened/closed as follows:

Opening/closing the fuel filler flap

Kraftstofftankklappe öffnen/schließen

Open the fuel filler flap with the button on the lighting switch panel. The flap opens as soon as the button is released.

The instrument cluster display shows an arrow next to the symbol, indicating which side the fuel filler cap is on.

  • Close the flap. Press it shut until a click confirms that it is closed.

Related information

- Refueling

Fuel filler flap - manual opening

The fuel filler flap can be opened by hand if electrical opening from the vehicle interior is not possible.

Kraftstofftankklappe - manuelles Öffnen
  1. Open/remove the side trim panel in the luggage compartment (on the same side as the fuel filler flap) and feel for the green pull cable with handle.
  2. Pull the cable carefully straight back until the fuel filler flap pops out with a click.
IMPORTANT

Pull the cable carefully - only minimal force is needed to release the flap lock.

Related information

- Refueling

Refueling

Always observe the following when refueling:

Fuel cap - opening/closing

Tankverschluss öffnen/schließen

At high outside temperatures, overpressure may build up in the tank. In this case, open the cap slowly.

  • After refueling, reinstall the cap and turn it until one or more clicks are heard.

Refueling

  • Do not fill the tank with too much fuel.

    Stop refueling when the fuel nozzle shuts off.

WARNING: A completely full tank may overflow in warm weather.

Refueling from a canister15

When refueling from a spare canister, use the funnel stored under the luggage compartment floor.

Make sure the funnel spout is inserted far enough into the filler pipe. The filler pipe contains a movable flap that must be opened by the funnel spout before the vehicle can be refueled.

Related information

  • Fuel filler flap - manual opening
  • Fuel - handling

15 Applies only to vehicles with diesel engines.

Fuel - handling

Do not use fuel of lower quality than that specified in Volvo's recommendations, as this negatively affects engine output and fuel consumption.

WARNING

Do not inhale gasoline vapors! Protect your eyes from fuel splashes.

If fuel gets into your eyes, remove any contact lenses and rinse the eyes with plenty of water for at least 15 minutes. Seek medical attention.

Do not swallow fuel! Fuels such as gasoline, bioethanol, mixtures of these two fuels, and diesel are extremely toxic and, if swallowed, can cause permanent injury or death. If fuel is swallowed, seek medical attention immediately.

WARNING

Fuel spilled on the ground can ignite.

Switch off any fuel-fired heater before refueling.

Never hold a switched-on mobile phone while refueling. The ringing signal can cause sparks and ignite gasoline vapors, which can lead to fire and injury.

IMPORTANT

Mixing different fuel types or using fuel not recommended by Volvo will void the Volvo warranty and any service agreements. This applies to all engines.

CAUTION

Extreme weather conditions, towing a trailer, or driving at high altitudes, in combination with fuel quality, are factors that can affect vehicle performance.

Related information

- Economical driving

- Fuel - diesel

- Diesel particulate filter (DPF)

- Fuel consumption and CO2 emissions

- Fuel tank - capacity

The fuel system of the Volvo S80 (2nd gen) is designed for convenience and safety. The fuel filler flap can be opened electrically or, if necessary, manually using a pull cable in the luggage compartment. When refueling, open the cap slowly in hot weather to release overpressure.

Refilling from a canister is also safely possible thanks to the included funnel. Volvo underlines its commitment to safety and everyday usability with well-thought-out details.

FAQ

How is the fuel filler flap opened manually?
Using the green pull cable in the luggage compartment on the fuel filler flap side. Pull carefully until the flap springs open.

Why not overfill?
A completely full tank may overflow in warm weather and create safety risks.

Test yourself

A quick Volvo S80 quiz: every answer comes with an explanation and a link to the manual page.