BMW X3 Quiz

Propeller shaft complete

In this manual: Propeller shaft complete
General information on preservation measures — 1Body cavity sealing — 1Body corrosion protection — 1Body repair instructions — 1Support members — 1Luggage compartment floor — 1Wheel wells — 1Side frame and door pillars — 1Roof outer skin — 1Dash cowl — 1Front trim panel — 1Rear trim panel — 1Side panels — 1Front side doors — 1Rear side doors — 1Front lid — 1Rear lid — 1Other flaps — 1Body special tools — 1General information — 1Handling brake fluids — 1Brake testing and bleeding — 1Front brakes — 1Rear brakes — 1Master brake cylinder — 1Brake lines — 1Brake booster — 1Electrical components/wear indicator — 1Parking brake — 1Mechanical/hydraulic components — 1Electronic components — 1Brakes — 1Front brake — 1Pedal mounting block — 1Brake pedal with linkage — 1Clutch pedal with linkage — 1Accelerator pedal actuation — 1Pedals — 1Specified grease — 1Propeller shaft, general — 1Propeller shaft assembly — 1Center console assembly — 1Front propeller shaft — 1Propeller shaft — 1Propeller shaft complete — 1Front axle repair instructions — 1Front axle suspension — 1Front sub-frame — 1Struts with rubber mounts — 1Wheel bearings and stub axle — 1Spring strut — 1Spring with suspension — 1Stabilizer bar — 1Front axle gearbox — 1Output shaft — 1Front axle — 1General information on high temperature multi-purpose grease — 1Rear axle repair instructions — 1Final drive with cover — 1Final drive mounting — 1Output shafts — 1Rear sub-frame — 1Control arms and struts — 1Axle mounting — 1Wheel bearings — 1Shock absorber — 1With suspension — 1Stabilizer bar — 1Rear axle — 1General information on final drive oil — 1Approved final drive oils for front and rear axle final drives with and without limited slip or viscous coupling — 1Final drive oil for bmw m1 motorsport coupe — 1Operating fluids as of 11/2015 — 1Brake pad replacement reminder — 1Emissions maintenance reminder — 1Maintenance service reminder — 1Tire pressure monitor system reminder — 1Description — 1Troubleshooting — 1Ignition wires, spark plugs — 1Ignition coil — 1Electronic switching or control units — 1Preheating relay — 1Preheater plugs — 1Alternator with drive and mounting — 1Controller — 1Starter with mounting — 1Starter lead — 1Engine wiring loom — 1Oil pressure/oil temperature/oil gauge — 1Switches and relays — 1Engine electrical system — 1Cabin air filter — 1Cabin air filter applications — 1Operating fluids - air conditioning and heating — 1Air conditioner refrigerant — 1Refrigeration oil — 1Note, overview components climate control — 1Heater with operation — 1Auxiliary. heater with control elements — 1Nozzles and outlets — 1Microfilter — 1Air conditioning, leak detection — 1Ac housing/evaporator, switching elements — 1Compressor — 1Condenser and dryer with lines — 1Heating and air conditioning — 1Front axle repair instructions — 1Front axle suspension — 1Front sub-frame — 1Struts with rubber mounts — 1Wheel bearings and stub axle — 1Spring strut — 1Spring with suspension — 1Stabilizer bar — 1Front axle gearbox — 1Front axle — 1General information on high temperature multi-purpose grease — 1Integrated suspension systems repair instructions — 1Front control and suspension elements — 1Rear control and suspension elements — 1Electrical components — 1Electronic damping force adjustment — 1Integrated suspension systems — 1Approved hydraulic fluids — 1Rear axle repair instructions — 1Final drive — 1Final drive with cover — 1Final drive mounting — 1Output shafts — 1Rear sub-frame — 1Control arms and struts — 1Axle mounting — 1Wheel bearings — 1Shock absorber — 1Springs with suspension — 1Stabilizer bar — 1Rear axle — 1General information on final drive oil — 1Approved final drive oils for front and rear axle final drives with and without limited slip or viscous coupling — 1Final drive oil for bmw m1 motorsport coupe — 1Operating fluids as of 11/2015 — 1Electronic chassis alignment — 1Mechanical steering gear — 1Steering gear with servo unit — 1Steering arms, tie rods, steer. damper — 1Steering column — 1Steering wheel — 1Steering wheel for airbag — 1Pump and oil supply — 1Steering and wheel alignment — 1Wheels — 1Disc wheels (rims) — 1Tires — 1Wheels with tires — 1Tire mounting paste — 1Engine mounting — 1Transmission suspension, automatic. transmission — 1Engine and gearbox suspension — 1Transmission in general — 1Transmission case, oil sump — 1Extension housing, bearings, seal — 1Mechanical attachments — 1Hydr/el control components/elements — 1Oil pump — 1Shift valves, parking lock — 1Torque converter — 1Automatic transmission — 1Automatic transmission fluid for zf-transmission GA8HP45Z / GA8HP50Z / GA8HP70Z / GA8HP90Z / GA8P70H / GA8P75H / GA8HP75Z — 1General information on automatic transmission fluids — 1Approved automatic transmission fluids for initial fillings and correcting fluid levels — 1Checking transmission fluid level — 1Transmission fluid change intervals (if applicable) — 1Transfer case, general — 1Transfer box — 1Transmission shafts — 1Transfer box special tools — 1Transfer box in general (atc 45l) — 1Transmission in general — 1Bearing in housing, sealing ring — 1SELF-DIAGNOSTICS DTCS — 1
~2min read

TIGHTENING TORQUE SPECIFICATION - PROPELLER SHAFT COMPLETE

 Type Thread Tightening specifications
1AZ

Front flexible disc to transmission output flange ZNS screws and nuts All versions

 Â Â Replace screws and nuts, jointing torque and angle of rotation must be observed without fail.

Tightening via screw
F01/F02/F03/F06/F07/F10/F11/F12/F13/F15

/F16/F18/F20/F21/F22/F23/F25/F26/F30

/F31/F32/F33/F34/F35/F36/F80/F82/F83/F18

PHEV/F15 PHEV

 M12- 10.9 Jointing torque Angle of rotation
2AZ

Front flexible disk to propeller shaft ZNS screws and nuts All versions

 Â Â Replace screws and nuts, jointing torque and angle of rotation must be observed without fail.

Tighten via nut
F01/F02/F03/F06/F07/F10/F11/F12/F13/F15

/F16/F18/F20/F21/F22/F23/F25/F26/F30

/F31/F32/F33/F34/F35/F36/F80/F82/F83/F18

PHEV/F15 PHEV

 M12- 10.9 Jointing torque Angle of rottation
3AZ

Flexible disc, rear, to transmission drive flange (inserted) ZNS screws and nuts All versions

 Â Â Replace screws and nuts, jointing torque and angle of rotation must be observed without fail.

Tightening via screw
F01/F02/F03/F06/F07/F10/F11/F12/F13/F18/F20

/F22/F23/F30/F31/F32/F33/F34/F36/F18 PHEV

 ASA M12- 10.9 Jointing torque Angle of rottation
4AZ

Flexible disc, rear, to propeller shaft ZNS screws and nuts All versions

 Â Â Replace screws and nuts, jointing torque and angle of rotation must be observed without fail.

Tighten via nut
F01/F02/F03/F06/F07/F10/F11/F12/F13/F18/F20

/F21/F22/F23/F30/F31/F32/F33/F34/F35/F36/F18 PHEV

 M12- 10.9 Jointing torque Angle of rotation
5AZ

Centre mount to body

 F01/F02/F03/F06/F07/F10/F11/F12/F13/F15/F16/F18/F20

/F21/F22/F23/F25/F26/F30/F31/F32/F33/F34/F35/F36/F18

PHEV/F15 PHEV

 Â Â
6AZ

Input flange, rear axle final drive (insert nut to propeller shaft/three- hole flange)

 F01/F02/F03/F06/F07/F10/F11/F12/F13/F18  Replace insert nut! Allow min. 2 hours hardening time Jointing torque Loosen the insert nut through 90º Tightening torque
F15/F16/F20/F22/F23/F25/F26/F30

/F31/F32/F33/F34/F35/F36/F18 PHEV/F15 PHEV

 Â Â
7AZ

Front propeller shaft to transfer box/front axle differential

 F01/F02/F06/F07/F10/F11/F12/F13/F15/F16/F20

/F21/F22/F23/F25/F26/F30/F31/F32/F33/F34/F36/F15 PHEV

 Â Replace screws, jointing torque and angle of rotation must be observed without fail.

Jointing torque Angle of rotation
8AZ

Constant velocity joint propeller shaft to rear axle differential

 F06 M6/F10 M5/F12 M6/F13 M6 M10 Replace screws and shims, jointing torque and angle of rotation must be observed without fail.

Jointing torque Angle of rotation
9AZ

Front propeller shaft to rear propeller shaft/constant velocity joint

 F06 M6/F10 M5/F12 M6/F13 M6 M12x1 Â

TIGHTENING TORQUE SPECIFICATION - PROPELLER SHAFT COMPLETE

 Type Thread Tightening specifications
1AZ

Propeller shaft plugged into rear axle final drive (insert nut)

 E9x/E82N54/E82N55/E88N54/E90

/E91/E92M57T2/Top/E89/

E84 N52K/E84 N55/E84

N20/E84 N47/E70/E71/E72

 Â Torque
2AZ

Propeller shaft plugged into rear axle final drive (insert nut)

 F25/F10N47 Â Torque
3AZ

Propeller shaft plugged into rear axle final drive (insert nut)

 F80 S55/F82 S55/F83 S55 Â Torque

Test yourself

A quick BMW X3 quiz: every answer comes with an explanation and a link to the manual page.